Stone Ballast Removal | Eagle Rivet

2021-10-29 · Stone Ballast Roofs. If you''ve ever seen a flat roof covered with gravel and wondered why, the answer is simple – it''s there to keep the roof in place. Stones have been used as roofing ballast since antiquity, and in its …

Gravel Ballasted Roofs

2021-12-17 · Gravel ballasted roofs with Sikaplan® or Sarnafil® single ply membranes are conventionally installed. The single ply membrane and other roof components, including thermal insulation, are loose laid. The buildup is …

Design of Loose-Laid Gravel Stone Ballasted Roofs ...

Roof areas subjected to different wind action require varying amounts of ballast. The amount of ballast varies from 50 to 65 kg/m² (10 to 13 psf) in conventionally …

Ballasted Roof System | Ballasted EPDM

Ballast stone can crush the underlying insulation, creating weak spots in the roof membrane. Over time, the stones move around, creating "Bald spots" where the system isn''t held down at all. In windy areas, ballast stone can actually blow off the roof, creating projectiles below. Stone ballast is no longer allowed by many building codes.

Ballast Can Do It All | Buildings

2008-8-13 · The stone used for (single-ply) ballast has been sized using ASTM D448. The wind performance of this material was extensively studied in wind tunnels and by field inspections during the 1970s and 1980s, resulting in the development of ANSI/SPRI/RP-4. The key reason for developing RP-4 was to eliminate improper use of stone ballast.

Chapter 15: Roof Assemblies and Rooftop Structures, NYC ...

Aggregate used as surfacing for roof coverings and aggregate, gravel or stone used as ballast shall not be used on the roof of a building located in a hurricane-prone region as defined in Section 1609.2, or on any other building with a mean roof height exceeding that permitted by Table 1504.8 based on the exposure category and basic wind speed ...

Roofing System Guide: Ballasted Roofing Systems

2015-1-15 · The Features. BUR''s and Ballast Roofing Systems (BRS''s) are topped with rocks. But the former uses a very thin layer of crushed stone or pea gravel that is not larger than 1/4th inch in diameter. This is partially-embedded into a …

Ballasted EPDM roof systems have been a sustainable …

The ballast usually can be reused or repurposed, and the EPDM membrane can be recycled or repurposed as a slip sheet between the new EPDM membrane and old ballast. LIMITATIONS Similar to any roof system, ballasted roofs have limitations and are not ideal for every building. First, ballast material is heavy, adding between 10 and 25 pounds per ...

Roof Ballast Stone Removal Services in Fort Worth and ...

Call Roofworx today at 817-920-5974 for roof ballast stone removal in Fort Worth, TX! Ballast Stone Removal in Texas. Whether you are replacing your current single-ply membrane roof, or if you are looking to install a new roof entirely, you …

Superior Ballast & Roof Vacuuming Services

2021-12-13 · Removing roof ballast, the RK Way, rather than with your own personnel, eliminates the most strenuous activity for ballasted low-slope roofs, saving you valuable project completion time, costly labor, and risk of personnel injuries. This applies to …

Ballast Paver

2015-4-2 · (perimeter pavers with stone ballast interior) 10 . Section 07555 Roof Ballast / Pavers Short Form Guide Specifications Part 1 - General 1.07 Delivery, Storage & Handling 1.01 Scope of Work A. Furnish and install Westile Ballast Paver system in accor-

Ballast Definition

Definition: What Does the Term Ballast Mean? Normally the reference to any weight that is designed to hold down a structure or roof. The construction reference, in many cases, is the layer of stone that is installed above a roof deck, whether it is a built up roofing system or a single ply system. Roof ballast can be an architectural material ...

All you need to know about: Inverted roof ballast – Total ...

2021-5-24 · The following roof covering specifications are deemed to satisfy performance requirements without the need for testing. • Loose laid gravel at least 50mm thick, or with a mass greater than 80 kg/m² (subject to maximum and minimum aggregate sizes). • Cast stone or mineral slabs at least 40mm thick. • A sand cement screed at least 30mm thick.

Superior Ballast & Roof Vacuuming Services

2  · Removing roof ballast, the RK Way, rather than with your own personnel, eliminates the most strenuous activity for ballasted low-slope roofs, saving you valuable project completion time, costly labor, and risk of personnel injuries. This applies to …

Ballast Netting

Ballast Netting. Ballast Netting is a cost-effective way to prevent Gulls and Crows from picking up and dropping ballast pebbles from height. If you would like to find out more about our Mesh Deterrent and Ballast Services, please request a …

S:FLEX

2021-12-15 · S:FLEX mounting rails are used as floor rails to mount the base triangles or as module carrier rails for vertical mounting. The hollow chamber rails are structurally optimised and available in different cross-sections and lengths. Rail connectors. To ensure structurally identical properties in the area of the rails and the connections.

A New Look at Ballasted Roofs | WATERPROOF! Magazine

2012-4-28 · In fact, the weight of the stone "ballast" is the only item holding the roof components in place. The weight can vary from 10 pounds per square foot (the minimum allowed by code) to 25 pounds or more. The most common assembly …

Ballast Removal, Re-Ballast, and Solar Panel Ballast Exchange

2021-12-18 · Ballast removal and re-ballast, or "swap-out"allows you to save on the cost of purchasing new ballast for your repair or re-roof jobs. This process begins with vacuuming all 1″ to 2.5" river rock from single-ply roof systems.

Ballasted Roof Systems: Costly Issues You Should …

Roof Damage from Foot Traffic. Another costly issue with ballast roof systems is that people accessing the roof tend to walk directly where they need to go and ignore walkways. Stepping directly on the stone ballast can result in excessive pressure pushing the stone into the membrane and creating a slice or hole.

Ballasted Roofs Meet Cool-Roof Criteria | Architect Magazine

2009-5-13 · Stone sizes were a nominal 1 1/2-inch (38-mm) diameter. One roof section had 10 pounds per square foot (49 kg/m2) of stone, the minimum allowed for ballast. Another roof section had 17 pounds per square foot (83 kg/m2) of ballast, and the third roof section featured 24 pounds per square foot (117 kg/m2).

The Purpose of Stone or Gravel Ballast ...

2019-9-19 · The Purpose of Stone or Gravel Ballast on a Flat Commercial or Industrial Roof It is not unusual to find a gravel top coat on commercial or industrial roofing systems. Though primarily confined to built-up asphalt roofing systems, …

Rooftop Detention (Blue Roofs)

The trays can be physically attached to the roof or underlying supporting grid and/or held in place with ballast comprised of coarse stone or other weighed materials. The depth of the ballast or media contained in the trays can be varied depending on the desire to reduce the presence of open water surfaces.

Stone Ballast Removal | Eagle Rivet

2021-10-29 · Stone Ballast Roofs. If you''ve ever seen a flat roof covered with gravel and wondered why, the answer is simple – it''s there to keep the roof in …

A1Grit

White Ballast. A1-Grit Ballast is a natural, smooth, water-worn and screened large gravel used for many applications. White Ballast can range in size from 2 1/2 - 3/4 inches and can be made to meet various ASTM standards. Our roofing Ballast is commonly installed over membrane and single-ply systems at 1000-1500 pounds per square.

Built Up Roof Materail Removal: Gravel | Ballast | Soil ...

Built-Up Roof Gravel and Ballast Removal. Adler Roof Vacuuming has been leading the industry for over 40 years. As the premier roof vacuuming company serving the entire east coast, you can rely on Adler for all of your roof vacuuming needs.BUR gravel and Ballast removal are just some of Adler''s roof vacuuming services.Read on to learn more about your options to protect an …

Sika-Trocal | Ballasted Single Ply Flat Roof Application

2021-12-8 · Gravel ballast of 20–40 mm diameter is required in order to provide resistance to the effects of wind scour, BRE Digest 311 (July 1988) refers, which can easily remove smaller units from the roof. The use of timber decking can also be considered as a ballasted application but due to its general lack of sufficient actual dead weight to resist ...

Ballast Paver Spec

2020-8-21 · 8. At center of roof, pavers may be cut to a minimum width of 6 inch. 9. Use ASTM #3 stone ballast at 12 lbs. per square foot on roof interior. ****OR**** A. Walkway System 1. Install minimum 18 inch wide a slip sheet under walkway. 2. Install single or multiple course walkway between roof access and maintained equipment locations.

Top Vac Canada Ballast Stone Removal

WELCOME. The "TOP VAC CANADA Advantage" - Specialized vacuum service for the removal of roof top ballast stone to loose fill attic insulation. We clear the way, making roofing and renovation jobs easier for roofers, contractors, businesses and homeowners. We have both the equipment and the expertise to get the job done, professionally ...

PMR Assembly: Blue Roofs

2019-5-2 · PMR Assembly Blue Roof. A Blue Roof can be created on a typical Hydrotech PMR (Protected Membrane Roof Assembly) utilizing standard loose stone for ballast. It is the simplest blue roof that can be created. Using standard …

Protected Membrane Roofing Ballast Options | American ...

Ballast Options and Flexibility. One of the advantages of using MM6125® in a Protected Membrane Roof Assembly (PMR) is that once the membrane is installed owners and designers can take advantage of various ballast options (gravel, pavers and Garden Roof®) to suit a specific project''s needs.

Apparatus and method for removing ballast stones from a …

1993-3-8 · Roof ballast stones are typically in the size range of 0.75 to 1.5 inches. One commercially available motorized gravel cart (as illustrated in FIG. 5) is the "Ballastmaster " machine available from Aeroil, Inc. The cart is directed from the roof 15 up either ramp 20, 22 of platform 12 and maneuvered so that the hopper of the removal machine is ...

Roof Ballast Rock Removal Services | Seal Roofing

Vacuuming, Roofing, and More. When you need high-quality roofing services that go beyond stone removal, Seal Roofing is a roofing industry leader. We offer everything from roof replacements and new construction to snow removal services for your business. Our roofing contractor expertise spans 30+ years and it shows.

Ballast Stone

Ballast stone is very effective when used as a base for agricultural construction. It is a excellent choice of bedding material because of it''s drainage properties. These properties promote the stabilization of roadways where water or traffic may cause soft sections. Producing Pattison Ballast Stone. Pattison produces Ballast Stone products ...

Copyright © 2007- AMC | Sitemap